The original daewootech forum

wolfhound wrote:
So from what I can see, there is no EGR anyway.

I'm guessing your engine came out of an auto... they don't have EGR

was the idle air control valve (IACV) replaced? you may need to clean your throttle body and if the IACV hasn't been replaced, clean that too

I used a 5 rib belt rather than 6 and it clears the chassis
also, I have a spare power steering bracket made by garrett if you're interested?

are saabs common in the US? there are hardly any here

the reason rocker covers on the 2.0l are so prone to leaking is because people love to over-tighten them.
they are listed at 8nm IIRC (5lb-ft)
also, there are o rings under each bolt that almost never get replaced and you're only meant to put sealant at the half moons

Red_LaNOS wrote:But i really don't want losses anywhere in the rev range.

no such thing as a free lunch

Idle Learn Procedure: 1. Ignition on for 5 sec. 2. Ign. off for 5 sec. 3. Ign. on for 5 sec. 4. Start the engine in P/N 5. Allow the engine to run 'til operating temp. is reached. 6. Turn a/c on for 10 sec. 7. Turn a/c off for 10 sec. 8. If auto. put your foot on the brake and shift to D 9. Turn a/c...

if the coolant sensor is disconnected, it will idle at 3000rpm (and if I were you, I'd check this connection first as it's right at the passenger side of the head) a disconnected oxygen sensor will also cause a high idle but only about 1500-1700rpm could it also be possible that wires were damaged w...

depends on what your powerband goal is

the pistons are bigger so you can machine the cylinder walls true at installation thus removing any high spots or glazing etc. re. throttle body swap: http://www.daewootech.com/forum/viewtopic.php?f=15&t=13091&start=15#p113512 also, some commodores run the same sensors on their throttles, the VS I t...

it only does it over a certain speed/rpm to maintain smoothness i.e coasting in 5th on the highway or coasting down a hill in a gear that maintains as much speed if it did it at low speeds/rpm, it would be very jerky guarantee your's did it Rodd but unless you have some sort of indicator, you would ...

yeah my lanos does it.

Also, welcome back Mohamed!

That's the law in oz... projectors, washers, and auto-levelers. But they don't check that yearly, only if you get pulled over...

That's right, MC is different as well as the proportioning valves

no, completely different well it is for the c20sed anyway... my daewoo 2.0 uses GMDelco management whereas the opels use bosch I'm guessing the reason you want to swap ecu is because you want access to flash tuning like EDS-IPF? the hassle you will go through (and price to get a loom and computer fr...